Click here for a PDF print version to use while you cook!
Corned Beef is a traditional meal of Irish-Americans, especially on St. Patrick's Day, or any cold winter day. But virtually ALL of the commercial uncooked corned beef that you find in the grocery store has added sodium nitrite; which is a commonly known carcinogen when present in cooked meats. So, here's how to make your own healthier corned beef, without the added chemicals!
And it is so easy to make and is a meal in itself! It only takes about 20 minutes to prepare then about 3 hours in a large pot on the stove.
Yield / servings
Allowing 1/2 pound (250 gm) of meat per person means that the average 4 to 6 lb. corned beef available at Costco serves 8 to 12 people.
Corned beef is not an Irish dish; it's connection with Saint Patrick's Day occurred in America in the Irish-American culture, How so? See this page for the history of corned beef and cabbage.
Background: First a bit of history helps you to understand what you're doing. "Corned Beef" is called that because, historically, the Irish preserved the beef by packing it in salt. The grains of salt were large and looks like kernels of corn. So, the beef was then called "corned beef". These days, the commercial meat producers also add sodium nitrite, as a preservative to make the meat look bright red, even after it has been cooked. Unfortunately, this also greatly increased the risk of colon cancer. According to the International Agency for Research on Cancer, ingested nitrite is probably carcinogenic to humans. For more information about the connection between sodium nitrite, cancer and processed meats, in plain English, see this page. But since you aren't going to be spending months crossing the Atlantic on the Mayflower, and you have a fridge and freezer, you can make corned beef without the sodium nitrite and the salt is unnecessary as well!
Steps to prep the brisket
Open the bag containing the brisket by slicing one end with a knife or scissors. We're going to re-use the bag.
Rinse your fresh beef brisket in the sink under cold water and rinse out the bag.
Stab the brisket about 20 or 30 times on each side
Mix HALF of the spices as below:
and then spread half of the spice mixture evenly in the bag, laid in the pan.
Lay the brisket in the bag.
Spread the spice mixture on top of the meat, and seal the bag. Press the spice mixture into the beef by pressing on the bag.
Press out excess air and tape it shut.
But the beef on a tray or shallow pan (in case there is any leakage) and put in the back of a cold fridge (32 - 40 F).
Now the beef simply ages for 3 to 5 days. 3 days is fine, but a couple more days is good if you have the time.
After a few days, when you are ready to start cooking, peel and chop one large onion. Remove the beef from the fridge and discard the bag.
Put the onion pieces into the bottom of a large pot .
Remove the beef from the packaging, do not rinse it off (it is seasoned), recover the spice packet and set it aside. Lay the whole piece of corned beef on top of the onions.
Add in the beer and water to the pot.
Sprinkle the spices into the pot:
Cover, and turn the stove on high to bring to a boil, then turn to medium or medium low to get a steady simmer.
Pretty simple, wash, peel the potatoes and carrots and cut them into roughly golf ball sized pieces. Or simply use small potatoes, wash thoroughly and then there is no need to peel!
After 3 hours add the potatoes and carrots. and put the cover back on.
Peel the outer leaves and wash the cabbage. Cut the cabbage into 8ths, cutting through the stem (it helps to hold it together in the pot). At 2.5 hours (in other words, a half hour after you add the potatoes and carrots) add the cabbage.(If you put it in earlier will become mushy!)
After 3 hours, it is done! The meat should be tender and start to fall apart as you cut it. The potatoes, carrots and cabbage should be tender.